Plane crash map Locate crash sites, wreckage and more

N6464V accident description

Alaska map... Alaska list
Crash location 63.783334°N, 146.066667°W
Reported location is a long distance from the NTSB's reported nearest city. This often means that the location has a typo, or is incorrect.
Nearest city Delta Junction, AK
64.037778°N, 145.732222°W
20.3 miles away
Tail number N6464V
Accident date 13 Sep 2015
Aircraft type Helio H 295
Additional details: None

NTSB Factual Report

On September 13, 2015, about 0840 Alaska daylight time, a tundra tire-equipped Helio Courier H-295 airplane, N6464V, sustained substantial damage during takeoff following a runway excursion from a remote unimproved airstrip near Delta Junction, AK. The airplane was being operated by Wright Air Service Fairbanks, Alaska, as a visual flight rules (VFR) on-demand charter flight under the provisions of 14 Code of Federal Regulations (CFR) Part 135.The certificated airline transport pilot and two passengers were not injured. Visual meteorological conditions prevailed, and a VFR flight plan had been filed. The flight departed a remote unimproved airstrip near Delta Junction, Alaska, at about 0840 destined for Fairbanks, AK.

During an interview with the National Transportation Safety Board (NTSB) investigator-in-charge (IIC) on September 14, the pilot stated that he was departing from a remote unimproved airstrip estimated to be about 850 feet long, with 800 feet usable. He stated that the airplane seemed to accelerate normally, but failed to become airborne at the departure end of the runway, and impacted brush and trees, sustaining substantial damage to the right wing.

In the recommendation section of the NTSB Accident/Incident Reporting Form 6120.1, the pilot went on to state that following the accident he departed the airstrip in the same make and model airplane with a similar load and the airplane lifted off in about 600 feet. In addition, he stated that it was possible that the engine was not producing full power even though the RPM was at redline, and there were no sounds associated with missing or a power reduction.

A Helio Courier training manual dated October 1968 provided a Takeoff Distance vs Density Altitude chart for hard surfaced runways, which included a ground run correction factor for wet grass and soft turf. At a density altitude of about 928 feet and a gross weight of about 3,340 pounds, the takeoff ground run with the wet grass correction factor was about 480 feet.

The airplane was equipped with a Lycoming GO-480-G1D6 engine, the pressure carburetor was replaced with a Bendix fuel injection system, under the Federal Aviation Administration (FAA) field approval process.

On October 2, the engine, while still mounted on the accident airplane's airframe, was operated under the direction of the IIC, along with the rest of the investigative team. The engine ran without any observed anomalies, and produced full factory specified rpm. A drop of about 25 RPM was noted for the left and right magnetos. A series of power adjustments from idle to full power were conducted with no hesitation in engine operation noted.

An aviation safety inspector from the Flight Standards Division, System Safety and Analysis Branch inspected the accident airplane following the engine run, and noted that the scat tube that joins the air box assembly to the air filter assembly was not secured to the filter assembly with the hose clamp as depicted in the Helio Courier parts manual.

The closest weather reporting facility was Allen Army Airfield, about 35 miles northeast of the accident site. At 0853, a weather observation from Allen Army Airfield was reporting, in part: wind calm; visibility, 10 statute miles; few clouds 1,000 feet, few clouds 13,000 feet, scattered clouds 17,000 feet, scattered clouds 20,000 feet; temperature, 28 degrees F; dew point 27 degrees F; altimeter, 30.14 inHG.

NTSB Probable Cause

A partial loss of engine power during takeoff for reasons that could not be determined because postaccident examination of the airframe and engine did not reveal any anomalies that would have precluded normal operation.

© 2009-2020 Lee C. Baker / Crosswind Software, LLC. For informational purposes only.